What would cause it to just shut off like a.

  • 1 POST
  • 250,000 MILES

What would cause it to just shut off like a switch while driving 40 mph? No sputter, it just stopped running. All electrical is functioning. It cranks fine but will not start. All electrical accessories work. Its like no spark to plugs, but just had new wires and cap put on 40000 miles ago.

Do you
have the same problem?
Tuesday, March 19th, 2013 AT 3:58 PM

1 Reply

  • 21,041 POSTS

All "crank, no start" conditions are approached in the same way. Every engine requires certain functions to be able to run. Some of these functions rely on specific components to work and some components are part of more than one function so it is important to see the whole picture to be able to conclude anything about what may have failed. Also, these functions can ONLY be tested during the failure. Any other time and they will simply test good because the problem isn't present at the moment.
If you approach this in any other way, you are merely guessing and that only serves to replace unnecessary parts and wastes money.

Every engine requires spark, fuel and compression to run. That's what we have to look for.

These are the basics that need to be tested and will give us the info required to isolate a cause.

1) Test for spark at the plug end of the wire using a spark tester. If none found, check for power supply on the + terminal of the coil with the key on.

2) Test for injector pulse using a small bulb called a noid light. If none found, check for power supply at one side of the injector with the key on.

3) Use a fuel pressure gauge to test for correct fuel pressure, also noticing if the pressure holds when key is shut off.

Once you have determined which of these functions has dropped out,
you will know which system is having the problem.

Was this
Tuesday, March 19th, 2013 AT 4:09 PM

Please login or register to post a reply.

Recommended Guides