Engine wont start

Tiny
NOKO1
  • MEMBER
  • 2000 FORD MUSTANG
I replace fuel pump relay electric, fuses are good so a don t have power to electric pump not even to relay and way a parking thi carr went tray to start motor crank dont start
Do you
have the same problem?
Yes
No
Saturday, August 7th, 2010 AT 5:22 PM

73 Replies

Tiny
KHLOW2008
  • MECHANIC
  • 41,815 POSTS
Hi noko1,

Do you mean the fuel pump relay does not have any voltage at terminal # 11? When you turn the key to the on position without cranking the engine over can you hear the fuel pump run in the tank for 5 seconds?

This guide should help us

https://www.2carpros.com/articles/car-cranks-but-wont-start

Please run down this guide and report back.

Was this
answer
helpful?
Yes
No
Sunday, August 8th, 2010 AT 2:16 AM
Tiny
NOKO1
  • MEMBER
  • 3 POSTS
You righ no volt I am hope it not thi EMC
Was this
answer
helpful?
Yes
No
Sunday, August 8th, 2010 AT 6:52 AM
Tiny
KHLOW2008
  • MECHANIC
  • 41,815 POSTS
At the left side of engine compartment in the Battery Junction Box, check the Fuel Pump Fuse ( 20 A ) use a test lamp to check if battery voltage is available. If fuse is bad replace it. If fuse is good and does not have any battery voltage, there is an open between the battery and the fuse, could be a fault with the fuse box or loose connection.

If fuse is good and voltage is not available at the relay, check the Light Blue/Orange wire to fuel pump relay for open circuit.

Note : If power is getting to the relay and coming out, check the inertia Fuel Shut Off Switch, located at lower left rear corner of trunk.
Was this
answer
helpful?
Yes
No
-1
Sunday, August 8th, 2010 AT 7:17 AM
Tiny
NOKO1
  • MEMBER
  • 3 POSTS
Now I have power on fuel pump becose replace CCRM but is it sonthing went I turn iignicion to start carr start shut off so kuit I can keep run it it sonthing go on and off you could hare it like relay and shut me fuel pump back off
Was this
answer
helpful?
Yes
No
-1
Sunday, August 15th, 2010 AT 11:05 AM
Tiny
KHLOW2008
  • MECHANIC
  • 41,815 POSTS
Sorry I am having difficulty understanding you and there is nobody around to help me out at the moment.

Hope I get you right.

You mean the engine is quitting after startiing. If the ddash indicators lights are not showing, you could have a faulty ignition switch that is not working at the RUN position.

You need to test if voltage is present at the ignition switch Black/Light Green, Red/Black, Red/ Light Green and Gray/Yellow wire. Wire.
Was this
answer
helpful?
Yes
No
Sunday, August 15th, 2010 AT 11:31 AM
Tiny
ZANYJB
  • MEMBER
  • 1 POST
I had this problem got a new fuel pump relay ! Bam all fixed.
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:56 PM
Tiny
APOLINARCITO
  • MEMBER
  • 2 POSTS
  • 2000 FORD MUSTANG
  • 6 CYL
Mustang not starting
-Fuel pump works, but only shoots a pump about 1/4 of what's normal. Force-grounded it, so there's spark and gas at engine, but still won't start.
-New fuel pump relay
-Will discuss further
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:56 PM (Merged)
Tiny
APOLINARCITO
  • MEMBER
  • 2 POSTS
As a note, we're not sure it's the fuel pump; it could be anything.
Also, my uncle, the one that's helping with the car, has to leave pretty soon here, so after a little while we might not need help anymore.
Thanks
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:56 PM (Merged)
Tiny
RASMATAZ
  • MECHANIC
  • 75,992 POSTS
To rule out the fuel pump you must use a fuel pressure tester -start here
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
JOHN_35120
  • MEMBER
  • 12 POSTS
  • 2000 FORD MUSTANG
  • 6 CYL
  • 2WD
  • AUTOMATIC
  • 92,000 MILES
I recently replaced my fuel pump and filter. It crank 2 times after. Now it just turns over. No fuel. Reset the switch and still nothing. What could be going wrong? Before I replaced it I had 4 hot wires going to the pump now I only got 3 hot wires going to the pump. Checked fuses and relays. Is the anything else I could try?
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
MASTERTECHTIM
  • MECHANIC
  • 4,749 POSTS
Did you check for a ground? Could be bad ground connection
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
JOHN_35120
  • MEMBER
  • 12 POSTS
How would I check for a bad ground connection? Thanks John
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
MASTERTECHTIM
  • MECHANIC
  • 4,749 POSTS


https://www.2carpros.com/forum/automotive_pictures/139033_no_20.jpg

Was this
answer
helpful?
Yes
No
+4
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
JOHN_35120
  • MEMBER
  • 12 POSTS
How many volts does the fuel pump have going to it? A contant 12v?
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
MASTERTECHTIM
  • MECHANIC
  • 4,749 POSTS
When you turn ey on it sends 12 volts for 2 seconds as a prime
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
JOHN_35120
  • MEMBER
  • 12 POSTS
Okie Dokie.I checked everything out. Got to looking and found the Fuel Pump Driver Module. Replaced it. Got power. But for some odd reason the power going to the fuel pump got hot and started melting.. Unplugged fuel pump and turned the key over and got power to my meter. The wire did not get hot then. There was a naked spot on the power wire in the fuel pump. LOL Thx to me. Could that be grounding out or shorting out In the fuel tank? Thanks John
Was this
answer
helpful?
Yes
No
+1
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
MASTERTECHTIM
  • MECHANIC
  • 4,749 POSTS
Absolutely. Something is wired backwards or arcing out.
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
2CP-ARCHIVES
  • MEMBER
  • 4,544 POSTS
  • 2000 FORD MUSTANG
  • 12,000 MILES
My car stalled like it was out of gas when I put gas in it an hour so later is started back up. Now its doing it again and this time it won't come on at all. I can no longer hear the
fuel pump when I turn the ignition. Do you think this is the fuel pump or relay?
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
ASEMASTER6371
  • MECHANIC
  • 52,797 POSTS
If you ran out of fuel, the pump was damaged and most likely needs to be replaced.

I would have the pressure verified before throwing any parts at it

Roy
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)
Tiny
KINGSHORSES
  • MEMBER
  • 1 POST
  • 2000 FORD MUSTANG
  • 6 CYL
  • 2WD
  • AUTOMATIC
  • 102,000 MILES
Car wont start. Removed the tank and fuel pump.
Purchased a used fuel pump DA oh well niether will work. I have power all the way to the pump.
One black wire and a pink and striped with black wire.
Turn key power to both sides. When you start it power loss from the black side pink stays on.
Will not prime will not pump! Whats up.
Roll over switch seems ok relay? And is there a programer switch huh?
Was this
answer
helpful?
Yes
No
Wednesday, November 27th, 2019 AT 6:57 PM (Merged)

Please login or register to post a reply.

Sponsored links