2005 Jaguar X-Type Replacing AC Compressor

Tiny
MAHERT
  • MEMBER
  • 2005 JAGUAR X-TYPE
Air Conditioning problem
2005 Jaguar X-Type 4 cyl Two Wheel Drive Manual

Hi,
Can anyone advise what is required to replace the AC compressor on a 2005 2 Lt Diesel X Type jaguar.
How is it accessed and what needs to be removed to enable compressor to be replacem.
Thanks,
tommy.
Do you
have the same problem?
Yes
No
Tuesday, October 27th, 2009 AT 5:04 PM

1 Reply

Tiny
DAVE H
  • EXPERT
Air Conditioning (A/C) Compressor
Removal
Reclaim the refrigerant. For additional information, refer to CLIMATE CONTROL SYSTEM-GENERAL INFORMATION.
Raise and support the vehicle. For additional information, refer to.
Detach the accessory drivebelt.
Using the special tool, rotate the belt tensioner counter clockwise.
Detach the accessory drivebelt
Fig. 2: Detaching Accessory Drivebelt
Courtesy of JAGUAR CARS, INC.
Disconnect the electrical connector.
Fig. 3: Disconnecting Electrical Connector
Courtesy of JAGUAR CARS, INC.
NOTE:Seal the tube and the compressor with plugs

Fig. 4: Detaching Compressor Supply And Return Tubes
Courtesy of JAGUAR CARS, INC.
Detach the compressor supply and return tubes.
Remove and discard the compressor O-rings.
Fig. 5: Removing Compressor O-Rings
Courtesy of JAGUAR CARS, INC.
Remove the compressor.
Fig. 6: Removing Compressor
Courtesy of JAGUAR CARS, INC.
Installation
NOTE:Install new O-ring seals.

NOTE:Coat the refrigerant line O-ring seals in clean refrigerant oil prior to installation.

NOTE:5oz of oil are contained in the new compressor. The air conditioning system requires a total of 7oz of oil.

To install, reverse the removal procedure.
Tighten to 25 N.M.
Fig. 7: Tightening Bolts With Torque Specification
Courtesy of JAGUAR CARS, INC.
Tighten to 25 N.M.
Was this
answer
helpful?
Yes
No
-1
Monday, November 30th, 2009 AT 7:36 PM

Please login or register to post a reply.

Recommended Guides