am not getting any heat. The engine warms up normally?

2001 FORD WINDSTAR

176,000 MILES

BONFIELDROSS

MEMBER
2 POSTS
FOLLOW

I have a 2001 Windstar ,3.8. and am not getting any heat . the engine warms up normally , not loosing antifreeze .. but when watching the antifreeze bottle , it does not go down , but warm antifreeze goes into the bottle. Would this mean the thermostat is stuck?

Recently changed upper rad hose , and all was fine till a week ago when the heat stopped, when engine is warmed, the upper rad hose is soft and squeezable.

Thanks for this site :-)

Feb 14, 2012 at 8:26 PM

SQM

CAR REPAIR CONTRIBUTOR
6,383 POSTS

Hello,

A sticking closed thermostat can impact the heater performance by restricting coolant flow.
Another common issue is a faulty blend door actuator, which could be stuck in the cold position and only allowing cold air to flow through the vents. The blend door actuator is located under the dash on the HVAC box.

https://www.2carpros.com/articles/car-heater-not-working

Keep in mind that when a thermostat fails at stuck closed position the engine could overheat.
Are you experiencing engine overheating?

https://www.2carpros.com/articles/symptoms-of-an-overheating-engine

I have attached diagrams for your reference.

Please let me know if you have any questions.
Thank you.

Images (Click to enlarge)

Jan 3, 2022 at 11:15 AM

Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.