1996 Toyota 4Runner sunroff

Tiny
ADR SR 64
  • MEMBER
  • 1996 TOYOTA 4RUNNER
  • 6.4L
  • 6 CYL
  • 4WD
  • AUTOMATIC
  • 166,600 MILES
Cant open sun roof on 96 4 runner, but moter clicks when pressing button but don't open
Do you
have the same problem?
Yes
No
Saturday, February 28th, 2015 AT 12:03 PM

1 Reply

Tiny
DR LOOT
  • EXPERT
It sounds like the motor gears stripped, here are the instructions on changing it

Removal & Installation (1996)

Disconnect negative battery cable. Remove rear interior light, rear header trim panel, and back door scuff plate. Remove rear door scuff plate, rear seat side trim, and deck side trim. Remove front door scuff plate. Remove center pillar lower trim panel. Remove front seat belt shoulder anchor. Remove center pillar upper trim panel.
Remove assist grips, and front pillar trim panel. Remove sun roof switch. See SUN ROOF SWITCH . Remove rear view mirror, sun visors, and front interior light. Release 5 clips, and remove headliner. Disconnect 4 drain hoses, and connectors from sun roof housing. Remove 2 nuts, 8 bolts and housing assembly. Remove sun shade trim. Remove side trim panel. Remove sun roof mounting nuts and glass.
Remove drip channel. Remove control relay, and drive gear assembly. Remove wind deflector. Remove sun roof housing. Remove drive rail. To install, reverse removal procedure.

SUN ROOF SWITCH
Removal & Installation

Disconnect negative battery cable. Pry sun roof switch assembly from roof panel. Remove screws and switch from switch panel. Unplug switch connector. To install, reverse removal procedure.
Was this
answer
helpful?
Yes
No
Saturday, February 28th, 2015 AT 6:24 PM

Please login or register to post a reply.

Recommended Guides