SPONSORED LINKS

Blower motor doesn't work

Tiny
MJSIMON
  • MEMBER
  • 2001 SATURN SL1
  • 4 CYL
  • 2WD
  • MANUAL
  • 160,000 MILES
I get 12 volts with the switch on and 0 when it is off, so I thought I needed to replace the blower motor. I installed a new one, but it still does not turn on.
Monday, October 12th, 2009 AT 12:26 PM

11 Replies

Tiny
IMPALASS
  • MECHANIC
  • 3,112 POSTS
Hello

Please check the HVAC fuse (15-amp), located in instrument panel fuse block. If fuse is blown replace as necessary. Please check it with an ohm meter or a known good fuse. Check for loose connections at blower motor relay, located in instrument panel fuse block. Here is the blower motor wiring diagrams and a guide to help you see where you lost power

https://www.2carpros.com/articles/how-to-use-a-test-light-circuit-tester

Check out the diagrams (Below). Please let us know what happens.
Image (Click to make bigger)
Thumb
SPONSORED LINKS
Was this
answer
helpful?
Yes
No
+2
Monday, October 12th, 2009 AT 1:51 PM
Tiny
MJSIMON
  • MEMBER
  • 2 POSTS
I tried both of your suggestions. I replaced the 15 amp fuse (though the old one looked fine) with a new one. I swapped the fuel pump relay with the one for the HVAC to see if that was the issue and did not get a difference. So I used the test light and found the connection at the relay was bad I fixed that and BAM! All fixed, thanks for your help I love this site.
Was this
answer
helpful?
Yes
No
Monday, October 12th, 2009 AT 2:55 PM
Tiny
JASON61580
  • MEMBER
  • 5 POSTS
  • 1999 SATURN SL1
  • 1.8L
  • 4 CYL
  • FWD
  • AUTOMATIC
  • 200,000 MILES
Heater started not to work then week ago or so fan stopped
Was this
answer
helpful?
Yes
No
Thursday, May 23rd, 2019 AT 2:18 PM (Merged)
Tiny
WRENCHTECH
  • MECHANIC
  • 20,757 POSTS
Start out by testing for power and ground at the motor to see which one is missing and that will determine which direction to go next.
Was this
answer
helpful?
Yes
No
Thursday, May 23rd, 2019 AT 2:18 PM (Merged)
Tiny
JASON61580
  • MEMBER
  • 5 POSTS
I was thinking that I'm going to try my idear first and see if they work I'm not sure if it has a cabin air filter but I'm going to go and check that first just in case
SPONSORED LINKS
Was this
answer
helpful?
Yes
No
Thursday, May 23rd, 2019 AT 2:18 PM (Merged)
Tiny
JASON61580
  • MEMBER
  • 5 POSTS
Saturn sl1 doesn't have cabin air filter so I'm going to remove blower test t on battery see if it turns
Was this
answer
helpful?
Yes
No
Thursday, May 23rd, 2019 AT 2:18 PM (Merged)
Tiny
JASON61580
  • MEMBER
  • 5 POSTS
Blower motor connector not the plug from car connector loose connection from blower how do I take apart blower to fix connector
Was this
answer
helpful?
Yes
No
Thursday, May 23rd, 2019 AT 2:18 PM (Merged)
Tiny
JASON61580
  • MEMBER
  • 5 POSTS
Nm just didn't want to break it found plastic cover wasn't sure
Was this
answer
helpful?
Yes
No
Thursday, May 23rd, 2019 AT 2:18 PM (Merged)
Tiny
SATURNTECH9
  • MECHANIC
  • 30,870 POSTS
His to add to this one you can't take the motor apart to fix the loose terminals inside you just have to replace the blower motor have ran across this before. To remove the motor you just unplug it and remove the three screws. Also inspect the Connector going to the motor I have seen the Connectors going to them melt.
Was this
answer
helpful?
Yes
No
Thursday, May 23rd, 2019 AT 2:18 PM (Merged)
Tiny
2CP-ARCHIVES
  • MEMBER
  • 4,542 POSTS
  • 2000 SATURN SL1
Blower motor not working, checked blower motor, it is good. Checked resistor, it is good. Where do we check next?
Was this
answer
helpful?
Yes
No
Wednesday, May 29th, 2019 AT 6:22 PM (Merged)
Tiny
SATURNTECH9
  • MECHANIC
  • 30,870 POSTS
When the blower motor is on high which are you missing at the blower motor connector battery voltage or ground?
Was this
answer
helpful?
Yes
No
Wednesday, May 29th, 2019 AT 6:22 PM (Merged)

Please login or register to post a reply.

Related Blower Fan Not Working Content

VIEW MORE

Sponsored links