Glow plug light on dash flashing loss of power.

Tiny
ANONYMOUS
  • MEMBER
  • 2010 VOLKSWAGEN PASSAT
  • 600,000 MILES
Glow plug light on dash flashing loss of power switched engine off driving normally again happened twice now
Friday, November 2nd, 2012 AT 10:03 PM

7 Replies

Tiny
EXOVCDS
  • MECHANIC
  • 1,883 POSTS
I have see this happen when the throttle body needs to be serviced here is a guide that will help us fix the problem.

https://www.2carpros.com/articles/throttle-actuator-service

Please run down this guide and report back.

Was this
answer
helpful?
Yes
No
Friday, November 2nd, 2012 AT 11:51 PM
Tiny
JC1WAY
  • MEMBER
  • 11 POSTS
  • 1996 VOLKSWAGEN PASSAT
  • 1.9L
  • 4 CYL
  • TURBO
  • FWD
  • MANUAL
  • 147,000 MILES
Bought a used vw tdi which instrument cluster was replaced with a no diesel cluster. There is no glow plug indicator light. Any suggestions on how to know when the glow plugs are warm and ready?
Was this
answer
helpful?
Yes
No
Thursday, April 30th, 2020 AT 11:09 AM (Merged)
Tiny
MHPAUTOS
  • MECHANIC
  • 31,938 POSTS
The glow duration is controlled by the engine coolant temp, colder the engine the longer the glow, what type of climate do you live in?
Was this
answer
helpful?
Yes
No
Thursday, April 30th, 2020 AT 11:09 AM (Merged)
Tiny
JC1WAY
  • MEMBER
  • 11 POSTS
I live in the mountains in Arizona. The lowest the temp gets is in the teens. It may have hit 0 a few times.
Was this
answer
helpful?
Yes
No
Thursday, April 30th, 2020 AT 11:09 AM (Merged)
Tiny
MHPAUTOS
  • MECHANIC
  • 31,938 POSTS
If you have to hold the key to control glow duration it will be a matter of trial and error extreme cold will require 4-5 sec at least, but yours should be controlled by the ecu so allow about the same time, the glow will shut down peak voltage and continue with after glow voltage for a while so allow about the same time, but you may have to experiment a little.
Was this
answer
helpful?
Yes
No
+1
Thursday, April 30th, 2020 AT 11:09 AM (Merged)
Tiny
JC1WAY
  • MEMBER
  • 11 POSTS
Thanks, I cleaned my throttle body
Was this
answer
helpful?
Yes
No
Thursday, April 30th, 2020 AT 11:09 AM (Merged)
Tiny
MHPAUTOS
  • MECHANIC
  • 31,938 POSTS
Just remember it is better to double glow at short duration then over glow and damage a glow plug, good luck with the cold weather.
Was this
answer
helpful?
Yes
No
Thursday, April 30th, 2020 AT 11:09 AM (Merged)

Please login or register to post a reply.

Sponsored links